Investigating heap leaching – the effect of feed iron concentration on bioleaching performance
| dc.contributor.author | van Hille, Robert P | |
| dc.contributor.author | van Zyl, Andries W | |
| dc.contributor.author | Spurr, Nicholas R L | |
| dc.contributor.author | Harrison, Susan T L | |
| dc.date.accessioned | 2016-08-17T10:03:59Z | |
| dc.date.available | 2016-08-17T10:03:59Z | |
| dc.date.issued | 2010 | |
| dc.date.updated | 2016-08-17T10:02:28Z | |
| dc.description.abstract | This paper describes an investigation into the effect of iron concentration in the leach solution on the bioleaching of a low grade copper ore, where chalcopyrite was the dominant copper sulphide. The concentration of dissolved iron is primarily controlled by pH and the relative proportion of ferric to ferrous iron, with significant jarosite precipitation occurring above pH ≈ 1.8 in a highly oxidised system. The solution pH may be increased by the dissolution of acid soluble gangue and when iron oxidation is significantly higher than sulphur oxidation. The study was approached using two experimental systems. In the former, the leach solution was recycled through an ore bed of low aspect (reactor height divided by diameter) ratio for a portion of the experiment. During the recycle phase, no acid was added to the system and acid consumption by gangue material led to a pH increase (1.6–2.2). The resulting jarosite precipitation reduced soluble iron from 2.5 g/l to less than 250 mg/l. Copper recovery decreased, but not in proportion to the decrease in iron. This was partly attributed to adsorption on, or entrainment within, the jarosites. To study the effect of reduced iron concentration on leach performance under more controlled conditions, bioleaching was performed in packed bed column reactors with feed iron concentrations ranging from 5 g/l to 200 mg/l. Observations indicated an initial decreased rate of copper liberation with reduced iron concentration in the feed. The relationship between available Fe3+ concentration and copper liberation was not proportional. However, with time, the liberation of copper became independent of iron concentration in the percolation liquor. Further, the specific rate of copper liberation was consistently below the theoretical value on a basis of ferric iron concentration. The highest values of copper liberation were reported at the lowest iron concentrations. In summary, while increased iron concentration in solution may enhance the initial rate of leaching, mineral availability appears to dominate CuFeS2 leach kinetics through the majority of the leach. Furthermore, high iron concentrations in solution aggravate jarosite formation with concomitant retention of copper in the ore bed. | en_ZA |
| dc.identifier | http://dx.doi.org/10.1016/j.mineng.2010.01.011 | |
| dc.identifier.apacitation | van Hille, R. P., van Zyl, A. W., Spurr, N. R. L., & Harrison, S. T. L. (2010). Investigating heap leaching – the effect of feed iron concentration on bioleaching performance. <i>Minerals Engineering</i>, http://hdl.handle.net/11427/21290 | en_ZA |
| dc.identifier.chicagocitation | van Hille, Robert P, Andries W van Zyl, Nicholas R L Spurr, and Susan T L Harrison "Investigating heap leaching – the effect of feed iron concentration on bioleaching performance." <i>Minerals Engineering</i> (2010) http://hdl.handle.net/11427/21290 | en_ZA |
| dc.identifier.citation | van Hille, R. P., van Zyl, A. W., Spurr, N. R., & Harrison, S. T. (2010). Investigating heap bioleaching: Effect of feed iron concentration on bioleaching performance. Minerals Engineering, 23(6), 518-525. | en_ZA |
| dc.identifier.issn | 0892-6875 | en_ZA |
| dc.identifier.ris | TY - Journal Article AU - van Hille, Robert P AU - van Zyl, Andries W AU - Spurr, Nicholas R L AU - Harrison, Susan T L AB - This paper describes an investigation into the effect of iron concentration in the leach solution on the bioleaching of a low grade copper ore, where chalcopyrite was the dominant copper sulphide. The concentration of dissolved iron is primarily controlled by pH and the relative proportion of ferric to ferrous iron, with significant jarosite precipitation occurring above pH ≈ 1.8 in a highly oxidised system. The solution pH may be increased by the dissolution of acid soluble gangue and when iron oxidation is significantly higher than sulphur oxidation. The study was approached using two experimental systems. In the former, the leach solution was recycled through an ore bed of low aspect (reactor height divided by diameter) ratio for a portion of the experiment. During the recycle phase, no acid was added to the system and acid consumption by gangue material led to a pH increase (1.6–2.2). The resulting jarosite precipitation reduced soluble iron from 2.5 g/l to less than 250 mg/l. Copper recovery decreased, but not in proportion to the decrease in iron. This was partly attributed to adsorption on, or entrainment within, the jarosites. To study the effect of reduced iron concentration on leach performance under more controlled conditions, bioleaching was performed in packed bed column reactors with feed iron concentrations ranging from 5 g/l to 200 mg/l. Observations indicated an initial decreased rate of copper liberation with reduced iron concentration in the feed. The relationship between available Fe3+ concentration and copper liberation was not proportional. However, with time, the liberation of copper became independent of iron concentration in the percolation liquor. Further, the specific rate of copper liberation was consistently below the theoretical value on a basis of ferric iron concentration. The highest values of copper liberation were reported at the lowest iron concentrations. In summary, while increased iron concentration in solution may enhance the initial rate of leaching, mineral availability appears to dominate CuFeS2 leach kinetics through the majority of the leach. Furthermore, high iron concentrations in solution aggravate jarosite formation with concomitant retention of copper in the ore bed. DA - 2010 DB - OpenUCT DP - University of Cape Town J1 - Minerals Engineering LK - https://open.uct.ac.za PB - University of Cape Town PY - 2010 SM - 0892-6875 T1 - Investigating heap leaching – the effect of feed iron concentration on bioleaching performance TI - Investigating heap leaching – the effect of feed iron concentration on bioleaching performance UR - http://hdl.handle.net/11427/21290 ER - | en_ZA |
| dc.identifier.uri | http://hdl.handle.net/11427/21290 | |
| dc.identifier.uri | http://www.sciencedirect.com/science/article/pii/S0892687510000233 | |
| dc.identifier.vancouvercitation | van Hille RP, van Zyl AW, Spurr NRL, Harrison STL. Investigating heap leaching – the effect of feed iron concentration on bioleaching performance. Minerals Engineering. 2010; http://hdl.handle.net/11427/21290. | en_ZA |
| dc.language | eng | en_ZA |
| dc.publisher | Elsevier | en_ZA |
| dc.publisher.institution | University of Cape Town | |
| dc.source | Minerals Engineering | en_ZA |
| dc.source.uri | http://www.sciencedirect.com/science/journal/08926875 | |
| dc.subject.other | Sulphide ores | |
| dc.subject.other | Hydrometallurgy | |
| dc.subject.other | Bioleaching | |
| dc.subject.other | Reaction kinetics | |
| dc.title | Investigating heap leaching – the effect of feed iron concentration on bioleaching performance | en_ZA |
| dc.type | Journal Article | en_ZA |
| uct.type.filetype | Text | |
| uct.type.filetype | Image | |
| uct.type.publication | Research | en_ZA |
| uct.type.resource | Article | en_ZA |